永利总站ylzz欢迎你_主站

您好,欢迎光临莱州聚峰机械有限公司网站!

服务热线

400-879-1999

你所在位置: 首页 >> 新闻资讯 > 行业资讯
行业资讯

全自动搅拌车不能搅拌了怎么处理?

来源:/ 时间:2023-03-20

全自动搅拌车搅拌器的动力由二级底盘的动力提取器通过传动轴传递给液压泵。液压泵产生的液压能量通过油管传递给液压马达。液压马达将液压能量转化为动能,通过减速机输送到搅拌槽。使用一段时间后,过多过少的搅拌桶就会出现搅拌不转的情况,一般有三种情况:
The power of the mixer of the fully automatic mixing truck is transmitted to the hydraulic pump through the transmission shaft by the power extractor of the secondary chassis. The hydraulic energy generated by the hydraulic pump is transmitted to the hydraulic motor through the oil pipe. The hydraulic motor converts hydraulic energy into kinetic energy and transmits it to the mixing tank through a reducer. After using for a period of time, too many or too few mixing drums will cause mixing to fail, generally in three situations:
1.混凝土在运输过程中被卡住;
1. The concrete is stuck during transportation;
2.液压系统或发动机故障;
2. Hydraulic system or engine failure;
3.马达出故障了。
The motor is out of order.
方案:
Solution:
混凝土在运输过程中被卡住;清理干净就没有问题了;
The concrete is stuck during transportation; Clean it up and there's no problem;
液压系统或发动机故障处理:
Troubleshooting of hydraulic system or engine faults:
(1)打开搅拌桶人孔盖,松开马达上高压软管的管接头,旋转搅拌桶使搅拌桶人孔斜向下,从搅拌桶人孔排出混凝土;
(1) Open the manhole cover of the mixing drum, loosen the pipe joint of the high-pressure hose on the motor, rotate the mixing drum to make the manhole of the mixing drum incline downward, and discharge concrete from the manhole of the mixing drum;
(2)麻烦卡车高压软管从救济的电动机用高压软管连接到另一端的油泵救援车,后将用于紧急回水管有麻烦卡车机油口、回油管另一端用泵抽油口后救援车辆,使用救援车来控制麻烦卡车的旋转圆柱,具体的排放。
(2) The high-pressure hose of the troublesome truck is connected from the relief motor to the oil pump rescue vehicle at the other end using a high-pressure hose, which will then be used to rescue the vehicle after the emergency water return pipe has an oil port of the troublesome truck, and the other end of the oil return pipe uses a pump suction port. The rescue vehicle is used to control the rotating cylinder of the troublesome truck, with specific emissions.
全自动搅拌车
电机故障,处理相对简单,可将电机从救援车上拆下安装在故障车上,然后将各油管连接起来,启动救援车时可将混凝土气缸混出。
The handling of motor faults is relatively simple. The motor can be removed from the rescue vehicle and installed on the faulty vehicle, and then all oil pipes can be connected. When starting the rescue vehicle, concrete cylinders can be mixed out.
全自动搅拌车作为运输车辆,应遵守交通部养护维修规定,实行“定期检查、强制养护、视情维修”的养护制度。在这个大前提下,结合全自动搅拌车的实际情况,做好养护维修工作。在日常养护方面,车辆应按照汽车发动机、底盘等部件的日常养护,还必须做好养护工作。更多相关内容就来我们网站咨询吧!
As a transportation vehicle, fully automatic mixer trucks should comply with the maintenance regulations of the Ministry of Communications, and implement a maintenance system of "regular inspection, mandatory maintenance, and maintenance as appropriate.". Under this premise, combined with the actual situation of fully automatic mixer trucks, maintenance and repair work should be done well. In terms of daily maintenance, vehicles should be maintained in accordance with the daily maintenance of automobile engines, chassis, and other components, and maintenance work must also be done well. For more relevant content, please visit our website Consult!
上一篇:永利总站ylzz欢迎你的使用从哪些事项做起?
下一篇:永利总站ylzz欢迎你购买时要知道什么内容
tag:永利总站ylzz欢迎你,永利总站ylzz欢迎你_主站,永利总站ylzz欢迎你_主站
当前位置: 首页 - 新闻资讯 > 行业资讯

全自动搅拌车不能搅拌了怎么处理?

作者:中科聚峰永利总站ylzz欢迎你厂家 时间:2023-03-20

全自动搅拌车搅拌器的动力由二级底盘的动力提取器通过传动轴传递给液压泵。液压泵产生的液压能量通过油管传递给液压马达。液压马达将液压能量转化为动能,通过减速机输送到搅拌槽。使用一段时间后,过多过少的搅拌桶就会出现搅拌不转的情况,一般有三种情况:
The power of the mixer of the fully automatic mixing truck is transmitted to the hydraulic pump through the transmission shaft by the power extractor of the secondary chassis. The hydraulic energy generated by the hydraulic pump is transmitted to the hydraulic motor through the oil pipe. The hydraulic motor converts hydraulic energy into kinetic energy and transmits it to the mixing tank through a reducer. After using for a period of time, too many or too few mixing drums will cause mixing to fail, generally in three situations:
1.混凝土在运输过程中被卡住;
1. The concrete is stuck during transportation;
2.液压系统或发动机故障;
2. Hydraulic system or engine failure;
3.马达出故障了。
The motor is out of order.
方案:
Solution:
混凝土在运输过程中被卡住;清理干净就没有问题了;
The concrete is stuck during transportation; Clean it up and there's no problem;
液压系统或发动机故障处理:
Troubleshooting of hydraulic system or engine faults:
(1)打开搅拌桶人孔盖,松开马达上高压软管的管接头,旋转搅拌桶使搅拌桶人孔斜向下,从搅拌桶人孔排出混凝土;
(1) Open the manhole cover of the mixing drum, loosen the pipe joint of the high-pressure hose on the motor, rotate the mixing drum to make the manhole of the mixing drum incline downward, and discharge concrete from the manhole of the mixing drum;
(2)麻烦卡车高压软管从救济的电动机用高压软管连接到另一端的油泵救援车,后将用于紧急回水管有麻烦卡车机油口、回油管另一端用泵抽油口后救援车辆,使用救援车来控制麻烦卡车的旋转圆柱,具体的排放。
(2) The high-pressure hose of the troublesome truck is connected from the relief motor to the oil pump rescue vehicle at the other end using a high-pressure hose, which will then be used to rescue the vehicle after the emergency water return pipe has an oil port of the troublesome truck, and the other end of the oil return pipe uses a pump suction port. The rescue vehicle is used to control the rotating cylinder of the troublesome truck, with specific emissions.
全自动搅拌车
电机故障,处理相对简单,可将电机从救援车上拆下安装在故障车上,然后将各油管连接起来,启动救援车时可将混凝土气缸混出。
The handling of motor faults is relatively simple. The motor can be removed from the rescue vehicle and installed on the faulty vehicle, and then all oil pipes can be connected. When starting the rescue vehicle, concrete cylinders can be mixed out.
全自动搅拌车作为运输车辆,应遵守交通部养护维修规定,实行“定期检查、强制养护、视情维修”的养护制度。在这个大前提下,结合全自动搅拌车的实际情况,做好养护维修工作。在日常养护方面,车辆应按照汽车发动机、底盘等部件的日常养护,还必须做好养护工作。更多相关内容就来我们网站咨询吧!
As a transportation vehicle, fully automatic mixer trucks should comply with the maintenance regulations of the Ministry of Communications, and implement a maintenance system of "regular inspection, mandatory maintenance, and maintenance as appropriate.". Under this premise, combined with the actual situation of fully automatic mixer trucks, maintenance and repair work should be done well. In terms of daily maintenance, vehicles should be maintained in accordance with the daily maintenance of automobile engines, chassis, and other components, and maintenance work must also be done well. For more relevant content, please visit our website Consult!

截屏,微信识别二维码