永利总站ylzz欢迎你_主站

您好,欢迎光临莱州聚峰机械有限公司官方网站!

服务热线

400-879-1999

你所在位置: 首页 >> 新闻资讯 > 行业资讯 >
行业资讯

全自动搅拌车的装料运输过程注意安全

来源:/ 时间:2022-10-26

全自动搅拌车的装料运输过程中,在您进行操作的时候一定要注意安全,不要出现相关的错误操作,当然在任何方面都应该仔细一点。下面来讲讲怎么安全装修并安全运输。
During the loading and transportation process of the fully automatic mixer, you must pay attention to safety when you operate, and do not make relevant mistakes. Of course, you should be careful in all aspects. Now let's talk about how to decorate and transport safely.
装料中
Loading
装料前应先将搅拌筒反转。车辆头班运行时尽可能先反转,因大多是露天停放,罐里可能会有积水、树叶等杂物,如不排出将影响混凝土质量。
The mixing drum shall be reversed before loading. During the first shift operation, the vehicle shall be reversed as far as possible. Because most vehicles are parked in the open air, there may be water, leaves and other debris in the tank. If it is not discharged, the concrete quality will be affected.
装完料要记得冲洗进料斗,要不然装料时散落的小石子容易凝固在接料斗内外和溜槽上,影响使用和美观。
After loading, remember to wash the feed hopper, otherwise the small stones scattered during loading will easily solidify inside and outside the receiving hopper and on the chute, affecting the use and beauty.
运输中
In transit
拐弯的时候一定要慢,搅拌车重心高,易侧翻!入弯之前提前减速减挡,尽量别拐弯的时候踩刹车。随时通过后视镜注意观察罐子是否在转,把转速尽量调慢,转速过高,车辆容易摆动。
When turning, you must be slow. The mixer truck has a high center of gravity and is easy to roll over! Slow down and downshift in advance before turning, and try not to brake when turning. Observe whether the tank is rotating through the rearview mirror at any time, and adjust the speed as slowly as possible. If the speed is too high, the vehicle is easy to swing.
全自动搅拌车
不好的路面低速挡通过,遇到路面不平、坑坑洼洼地方用合适的低速挡通过,保证车子的动力充沛。遇到大坑,石头,钢筋,铁块尽量避让,尤其重车。
If the road surface is not good, use a low gear to pass through uneven and potholed areas, so as to ensure that the car has sufficient power. Avoid big pits, stones, steel bars and iron blocks, especially heavy vehicles.
上坡好是提前减档,如果拉得满的话,注意起步要平缓,上坡更要注意,不能乱减挡,好提前减挡。同时,好加快罐子的转速,已免混凝土流出。
When going uphill, you should downshift ahead of time. If you pull full, you should start slowly. When going uphill, you should pay more attention. You should not downshift randomly, so you can downshift ahead of time. At the same time, it is good to speed up the rotation speed of the tank to prevent concrete from flowing out.
下坡切勿重车空挡滑行,长时间行驶或者下坡前都要挂入合适档位行驶。切勿重车空挡滑行下坡。下坡拐弯时提前减速然后再减挡再减速,带挡刹车效果好。
Do not coast with heavy vehicles in neutral gear when going downhill. Drive in proper gear for a long time or before going downhill. Do not slide downhill with loaded vehicles in neutral gear. When going downhill and turning, decelerate in advance, then downshift and decelerate again. The effect of braking in gear is good.
一定要注意限高问题,工地路况复杂,要小心树木等,特别是要防止刮到电线。
Attention must be paid to the problem of height limit. The road conditions on the construction site are complex, so be careful of trees, especially to prevent scraping the wires.
全自动搅拌车的装料运输过程中的正确操作就讲解到这里了,为了人员安全以及设备完好着想,您要多去了解多去牢记注意事项。关注我们了解更多!
The correct operation of the fully automatic mixer during loading and transportation will be explained here. For the sake of personnel safety and equipment integrity, you should learn more and remember the precautions. Follow us Learn more!
上一篇:永利总站ylzz欢迎你在维修中需要注意三点
下一篇:永利总站ylzz欢迎你_主站的刹车片要挑选合格
tag:永利总站ylzz欢迎你,永利总站ylzz欢迎你_主站,永利总站ylzz欢迎你_主站
当前位置: 首页 - 新闻资讯 > 行业资讯 >

全自动搅拌车的装料运输过程注意安全

作者:中科聚峰永利总站ylzz欢迎你厂家 时间:2022-10-26

全自动搅拌车的装料运输过程中,在您进行操作的时候一定要注意安全,不要出现相关的错误操作,当然在任何方面都应该仔细一点。下面来讲讲怎么安全装修并安全运输。
During the loading and transportation process of the fully automatic mixer, you must pay attention to safety when you operate, and do not make relevant mistakes. Of course, you should be careful in all aspects. Now let's talk about how to decorate and transport safely.
装料中
Loading
装料前应先将搅拌筒反转。车辆头班运行时尽可能先反转,因大多是露天停放,罐里可能会有积水、树叶等杂物,如不排出将影响混凝土质量。
The mixing drum shall be reversed before loading. During the first shift operation, the vehicle shall be reversed as far as possible. Because most vehicles are parked in the open air, there may be water, leaves and other debris in the tank. If it is not discharged, the concrete quality will be affected.
装完料要记得冲洗进料斗,要不然装料时散落的小石子容易凝固在接料斗内外和溜槽上,影响使用和美观。
After loading, remember to wash the feed hopper, otherwise the small stones scattered during loading will easily solidify inside and outside the receiving hopper and on the chute, affecting the use and beauty.
运输中
In transit
拐弯的时候一定要慢,搅拌车重心高,易侧翻!入弯之前提前减速减挡,尽量别拐弯的时候踩刹车。随时通过后视镜注意观察罐子是否在转,把转速尽量调慢,转速过高,车辆容易摆动。
When turning, you must be slow. The mixer truck has a high center of gravity and is easy to roll over! Slow down and downshift in advance before turning, and try not to brake when turning. Observe whether the tank is rotating through the rearview mirror at any time, and adjust the speed as slowly as possible. If the speed is too high, the vehicle is easy to swing.
全自动搅拌车
不好的路面低速挡通过,遇到路面不平、坑坑洼洼地方用合适的低速挡通过,保证车子的动力充沛。遇到大坑,石头,钢筋,铁块尽量避让,尤其重车。
If the road surface is not good, use a low gear to pass through uneven and potholed areas, so as to ensure that the car has sufficient power. Avoid big pits, stones, steel bars and iron blocks, especially heavy vehicles.
上坡好是提前减档,如果拉得满的话,注意起步要平缓,上坡更要注意,不能乱减挡,好提前减挡。同时,好加快罐子的转速,已免混凝土流出。
When going uphill, you should downshift ahead of time. If you pull full, you should start slowly. When going uphill, you should pay more attention. You should not downshift randomly, so you can downshift ahead of time. At the same time, it is good to speed up the rotation speed of the tank to prevent concrete from flowing out.
下坡切勿重车空挡滑行,长时间行驶或者下坡前都要挂入合适档位行驶。切勿重车空挡滑行下坡。下坡拐弯时提前减速然后再减挡再减速,带挡刹车效果好。
Do not coast with heavy vehicles in neutral gear when going downhill. Drive in proper gear for a long time or before going downhill. Do not slide downhill with loaded vehicles in neutral gear. When going downhill and turning, decelerate in advance, then downshift and decelerate again. The effect of braking in gear is good.
一定要注意限高问题,工地路况复杂,要小心树木等,特别是要防止刮到电线。
Attention must be paid to the problem of height limit. The road conditions on the construction site are complex, so be careful of trees, especially to prevent scraping the wires.
全自动搅拌车的装料运输过程中的正确操作就讲解到这里了,为了人员安全以及设备完好着想,您要多去了解多去牢记注意事项。关注我们了解更多!
The correct operation of the fully automatic mixer during loading and transportation will be explained here. For the sake of personnel safety and equipment integrity, you should learn more and remember the precautions. Follow us Learn more!

截屏,微信识别二维码