永利总站ylzz欢迎你_主站

您好,欢迎光临莱州聚峰机械有限公司官方网站!

服务热线

400-879-1999

你所在位置: 首页 >> 新闻资讯 > 行业资讯 >
行业资讯

永利总站ylzz欢迎你_主站高噪声的六点原因

来源:/ 时间:2022-10-10

有人咨询过这样的问题,永利总站ylzz欢迎你_主站在工作中有时候会出现高噪音的情况,噪音的出现肯定不是偶然,一定存在某种原因所致,具体原因如下:
Someone has inquired about the problem that small concrete mixers sometimes make high noise during work. The noise must not be accidental, but it must be caused by some reason. The specific reasons are as follows:
1、永利总站ylzz欢迎你_主站油箱液位过低,并且油液中的空气被吸入泵中。如果发生这种情况,您可以添加带有相同类型的液压油。
1. The oil tank level of small concrete mixer truck is too low, and the air in the oil is sucked into the pump. If this happens, you can add hydraulic oil with the same type.
2、如果泵的安装支架不牢固,在工作期间会产生振动和噪音。在这种情况下,可以加固油泵支架。
2. If the mounting bracket of the pump is not secure, vibration and noise will occur during operation. In this case, the oil pump bracket can be reinforced.
3、堵塞的滤芯会使吸油困难或者不充分。这种情况下,一定要及时清洁滤芯或更换滤芯。
3. Blocked filter element will make oil absorption difficult or insufficient. In this case, the filter element must be cleaned or replaced in time.
永利总站ylzz欢迎你_主站
4、如果液压油不符合要求或者是油太粘,请更换符合要求的低粘度液压油。
4. If the hydraulic oil does not meet the requirements or the oil is too viscous, replace the qualified low viscosity hydraulic oil.
5、永利总站ylzz欢迎你_主站储罐中有坚硬的混凝土。如果发生这种情况,及时清理并铲除干净。
5. There is hard concrete in the tank of small concrete mixer. If this happens, clean up and remove it in time.
6、万向传动轴之间的连接角度以及传动轴与取力器之间的连接角度太大,如果松开会产生噪音,在这种情况下,请在时间内检查并拧紧。
6. The connection angle between the universal drive shaft and between the drive shaft and the power take-off is too large. If it is loosened, it will make noise. In this case, please check and tighten it within a time.
永利总站ylzz欢迎你_主站高噪声的六点原因就是如此了,您对此可以认真作为参考看看,还有什么使用问题或者需求可以随时来我们网站咨询!
There are six reasons for the high noise of small concrete mixer trucks. You can take this as a reference carefully. If you have any questions or needs, please come to our website at any time consulting service
上一篇:搅拌车在注入油前需要注意的动作要注意
下一篇:搅拌车配件刹车系统维护与保养
tag:永利总站ylzz欢迎你,永利总站ylzz欢迎你_主站,永利总站ylzz欢迎你_主站
当前位置: 首页 - 新闻资讯 > 行业资讯 >

永利总站ylzz欢迎你_主站高噪声的六点原因

作者:中科聚峰永利总站ylzz欢迎你厂家 时间:2022-10-10

有人咨询过这样的问题,永利总站ylzz欢迎你_主站在工作中有时候会出现高噪音的情况,噪音的出现肯定不是偶然,一定存在某种原因所致,具体原因如下:
Someone has inquired about the problem that small concrete mixers sometimes make high noise during work. The noise must not be accidental, but it must be caused by some reason. The specific reasons are as follows:
1、永利总站ylzz欢迎你_主站油箱液位过低,并且油液中的空气被吸入泵中。如果发生这种情况,您可以添加带有相同类型的液压油。
1. The oil tank level of small concrete mixer truck is too low, and the air in the oil is sucked into the pump. If this happens, you can add hydraulic oil with the same type.
2、如果泵的安装支架不牢固,在工作期间会产生振动和噪音。在这种情况下,可以加固油泵支架。
2. If the mounting bracket of the pump is not secure, vibration and noise will occur during operation. In this case, the oil pump bracket can be reinforced.
3、堵塞的滤芯会使吸油困难或者不充分。这种情况下,一定要及时清洁滤芯或更换滤芯。
3. Blocked filter element will make oil absorption difficult or insufficient. In this case, the filter element must be cleaned or replaced in time.
永利总站ylzz欢迎你_主站
4、如果液压油不符合要求或者是油太粘,请更换符合要求的低粘度液压油。
4. If the hydraulic oil does not meet the requirements or the oil is too viscous, replace the qualified low viscosity hydraulic oil.
5、永利总站ylzz欢迎你_主站储罐中有坚硬的混凝土。如果发生这种情况,及时清理并铲除干净。
5. There is hard concrete in the tank of small concrete mixer. If this happens, clean up and remove it in time.
6、万向传动轴之间的连接角度以及传动轴与取力器之间的连接角度太大,如果松开会产生噪音,在这种情况下,请在时间内检查并拧紧。
6. The connection angle between the universal drive shaft and between the drive shaft and the power take-off is too large. If it is loosened, it will make noise. In this case, please check and tighten it within a time.
永利总站ylzz欢迎你_主站高噪声的六点原因就是如此了,您对此可以认真作为参考看看,还有什么使用问题或者需求可以随时来我们网站咨询!
There are six reasons for the high noise of small concrete mixer trucks. You can take this as a reference carefully. If you have any questions or needs, please come to our website at any time consulting service

截屏,微信识别二维码